Regency FP90 Manual de usuario

FPI FIREPLACE PRODUCTS INTERNATIONAL LTD. 6988 Venture St., Delta, BC Canada, V4G 1H404/04/08Tested by:Installer: Please complete the details on the

FPI FP90 Wood Fireplace10INSTALLATIONFire StopFireStopStraightrunfor 8"(203mm)Hot Air DuctUnit projectsout flush withnon-combustible ma

FPI FP90 Wood Fireplace 11INSTALLATIONVentilated Chase PanBEFORE YOU START Check your inventory list to be sure you have all the necessary parts supp

FPI FP90 Wood Fireplace12INSTALLATIONINSTALLATION MEASUREMENTS / FRAMING DETAILSINSTALLATION3"(76mm)STAND-OFF2x4FRAMINGFRONT OFUNIT ONLYCOMBUS

FPI FP90 Wood Fireplace 13INSTALLATIONThere is also 1" unit base standoffs that are supplied with the unit. These are optional and are to be used

FPI FP90 Wood Fireplace14INSTALLATION The performance of your unit is governed to a very large extent by the chimney system. Too short a chimney can

FPI FP90 Wood Fireplace 15INSTALLATIONINSTALLING THE OUTSIDE AIR KITCombustion air is fed to the fi rebox through a connection on the rear lower left s

FPI FP90 Wood Fireplace16INSTALLATIONPlan ViewJakel AX-2495 BlowerAngle ViewFan Transfer PlateRight ViewFront ViewFan 910-175 AX-3088910-903 910-516Gr

FPI FP90 Wood Fireplace 17INSTALLATIONFlex VentDischargeVent GrilleDischarge Vent FrameConnectingCollarClampFlexVentInsulation Strips1) Remove the s

FPI FP90 Wood Fireplace18INSTALLATION... Metal Filler StripsMetal Filler StripsMIDDLE UPTOP UPLEFT SIDE UPRIGHT SIDE UPACBBNon-Combustible

FPI FP90 Wood Fireplace 19INSTALLATIONNon-CombustibleMaterialMetalFillerStripsStand-off SpacersMetal Filler Strip60" (1524mm)CABB3/4" (19mm)

FPI FP90 Wood Fireplace2Thank-you for purchasing a REGENCY FIREPLACE PRODUCT.The pride of workmanship that goes into each of our products will give yo

FPI FP90 Wood Fireplace20INSTALLATIONSide PanelTopPanelInsulationTopBrickBottomVermiculiteMASONRY LINER / BRICKSInsulated refractory panels are includ

FPI FP90 Wood Fireplace 21INSTALLATIONASH DRAWER KIT OPTION During constant use, ashes should be removed every few days. The Ash Drawer Kit option pro

FPI FP90 Wood Fireplace22INSTALLATIONFAN INSTALLATIONNOTE: If optional Ashtray is installed, it must be removed before installing the fan. The rece

FPI FP90 Wood Fireplace 23INSTALLATIONMASONRY COVER PLATE INSTALLATION5°INSTALL FOUR #8x1/2 SCREWSAT THESE LOCATIONS TO ATTACHTHE SURROUND TEMPLATE SI

FPI FP90 Wood Fireplace24INSTALLATIONWITH THE SAME MOUNTING SCREWS AS THE SURROUND.INSTALL THE SURROUND TEMPLATE ONTO THE UNITWARNING: KEEP MASONRY MA

FPI FP90 Wood Fireplace 25INSTALLATIONFINISHING TRIM KIT INSTALLATION2x4 FRAMINGLEFT SIDE TRIMRIGHT SIDE TRIM2x4 FRAMINGTOP TRIMSTEP #1NON-COMBUSTIBLE

FPI FP90 Wood Fireplace26INSTALLATION2) Make sure the insulation under the top stand-off is up against the back of the top nailing strip.3) Fasten t

FPI FP90 Wood Fireplace 27INSTALLATIONFIREPLACE SCREEN INSTALLATIONINSTALLING THE HANDLES ON THE SCREEN1) 1 or 2 handles can be installed on the scree

FPI FP90 Wood Fireplace28INSTALLATIONREGENCY LOUVER INSTALLATIONInstalling the Top Louver1) Add two (2) screws (¼-20 X ½”) to the front of the fi repl

FPI FP90 Wood Fireplace 29INSTALLATIONInstalling the Facing Guide1) Secure the left and right facing guides to the fi re-place with seven (7) screws (

FPI FP90 Wood Fireplace 3TABLE OF CONTENTSSAFETY LABELSafety Label For FP90 ...4INSTALLATIONProduct D

FPI FP90 Wood Fireplace30INSTALLATIONEXCALIBUR ACCENT KIT INSTALLATION3) Remove the 2 studs on the sides of the Hood. Insert the new studs through th

FPI FP90 Wood Fireplace 31HEATWAVE KITHEATWAVE KIT (NOT EPA APPROVED)Diagram 1: Guide for possible air duct runs and locations. Keep duct length and n

FPI FP90 Wood Fireplace32HEATWAVE KITHEATWAVE KIT (NOT EPA APPROVED)MINIMUM FRAMING CLEARANCES* Wall studs must be 16" on center for mounting fa

FPI FP90 Wood Fireplace 33HEATWAVE KITHEATWAVE KIT (NOT EPA APPROVED)Diagram 44) Install the variable speed Wall Rheostat (with OFF setting) in a con

FPI FP90 Wood Fireplace34OPERATIONOPERATING INSTRUCTIONSDraft ControlBoth the primary and air wash drafts are controlled by the control rod located be

FPI FP90 Wood Fireplace 35MAINTENANCEPLATED FINISHESThe optional plated fi nishes on the louvers and surrounds requires little maintenance and needs o

FPI FP90 Wood Fireplace36PARTS LISTPARTS LISTPARTS LIST- FIREBOX & BODY161213151442187653 Part # Description1) 001-127 Heat Deflector Top

FPI FP90 Wood Fireplace 37PARTS LISTPARTS LISTPARTS LIST- BAFFLES, DOOR, OPTIONSSteel Handle - Left DoorSteel Handle - Right DoorAnchor Bracket - Left

FPI FP90 Wood Fireplace38NOTES________________________________________________________________________________________________________________________

FPI FP90 Wood Fireplace 39WARRANTYRegency Fireplace Products are designed with reliability and simplicity in mind. In addition, our internal Quality A

FPI FP90 Wood Fireplace4SAFETY LABELSAFETY LABEL FOR FP90This is a copy of the label that accompanies each Regency Fireplace. It is located inside th

Installer: Please complete the following informationDealer Name & Address: _______________________________________________________________________

FPI FP90 Wood Fireplace 5INSTALLATIONINSTALLATIONPRODUCT DETAILSEPA Certifi ed Emissions : 3.72 g/hr Effi ciency (EPA) : 63% BTU/HR (EPA) :

FPI FP90 Wood Fireplace6INSTALLATIONINSTALLATION6) Use solid fuel only. DO NOT use artifi cial logs containing petroleum products, chemical chimney cl

FPI FP90 Wood Fireplace 7INSTALLATION38"43- 5/8"14- 5/8"13-3/8"28"9-5/8"25"15"4-3/4"50- 1/2" (1283m

FPI FP90 Wood Fireplace8INSTALLATIONNo Combustibles on Face of Unit.Combustibles May Not Extend to Unit Face.Do not notch wallboard around standoffs.T

FPI FP90 Wood Fireplace 9INSTALLATIONBuilding Structures Cannot Encroach on Chase50-3/4"(1289mm)44"(1118mm)INSTALLATION OF NAILING STRIPS1)